How to Change the Oil in a 2005 Yamaha TTR90

Shop parts for a 2005 Yamaha TTR90 Dirt Bike.

If you ride a 2005 Yamaha TTR90, regular oil changes are crucial for engine health and long-term reliability. This step-by-step guide employs best practices and call-outs specific to the TTR90 model, helping you complete the job confidently—proudly presented by MotoSport.com.

Tools and Supplies Needed

  • 12mm socket with extension and ratchet
  • Oil drain pan
  • Funnel
  • New engine oil (consult your owner’s manual for oil type and amount; standard is 10W-40 or 10W-30 for most temperatures)
  • Clean rag or shop towels
  • Gloves (optional but recommended)

Preparation Steps

  • Warm up the engine: Start the bike and let it run for 5–10 minutes, or take a short ride to allow the oil to warm up. This thins the oil, allowing it to drain more thoroughly.
  • Make sure the bike is on a level surface and the engine is off before you begin work.

Step-by-Step Guide

  1. Locate the Oil Components
    • The oil fill cap and dipstick are on the right side of the engine.
    • The oil drain bolt is located underneath the bike, near the bottom of the engine. It is a 12mm bolt and can be set back slightly—having an extension on your socket wrench will make reaching it easier.
  2. Remove the Dipstick
    • Unscrew and remove the dipstick. This allows air into the crankcase and helps oil drain faster and more completely.
  3. Drain the Old Oil
    • Position the oil drain pan below the drain bolt.
    • Using the 12mm socket and extension, loosen and remove the drain bolt. Be careful—oil may flow quickly once you crack the bolt loose.
    • Allow the oil to drain completely. Be patient and let it drip until the flow stops. Warming the engine beforehand ensures a more complete drain.
    • Inspect the drain bolt and washer for wear or damage; replace if necessary.
  4. Reinstall the Drain Bolt
    • Clean the drain bolt and the sealing surface on the engine.
    • Reinstall the bolt snugly—do not over-tighten to avoid stripping the threads, which is a common mistake.
  5. Refill with Engine Oil
    • Insert a funnel into the fill hole as needed.
    • Pour in the oil—the TTR90 requires approximately 1 liter (about 1 quart) of oil, but always check the owner’s manual for your year/model specifics.
    • Replace the dipstick but do not screw it in. Remove, and check that the oil level is between the two marks or notches on the stick. Add oil a little at a time if needed.
  6. Check for Leaks and Final Level
    • Start the engine and let it idle for 1–2 minutes, then shut it off and wait a couple of minutes for the oil to settle.
    • Check the oil level again and top off if necessary.
    • Inspect the drain plug area for leaks.
  7. Cleaning Up
    • Dispose of the used oil in accordance with local regulations. Many auto parts stores accept used oil for recycling.
    • Wipe off any drips or spills and check that the bike is clean and ready for the next ride.

2005 Yamaha TTR90-Specific Notes & Tips

  • No Oil Filter: The TTR90 does not use a traditional replaceable oil filter. Maintenance is simplified, but this makes frequent oil changes even more important.
  • The drain plug position can be tight to reach, so a socket extension is highly recommended.
  • Be sure to properly identify your exact year and sub-model by checking the VIN on the frame (details on interpreting VIN is often found in your manual).
  • Oil color or smell: If your oil smells of gasoline or is very dark, change it promptly—this can result from an over-rich carburetor or leaving the choke on while riding.
  • If your TTR90 has been sitting for some time, oil may be contaminated or contain fuel; always change oil before resuming regular use

Engine Oil Specification

  • Typical oil type for the 2005 TTR90: 10W-40 or 10W-30 motorcycle engine oil.
  • Oil capacity: About 1 liter (1.1 US quarts).
  • Always use motorcycle-specific oil to protect clutch and gearbox components.

Conclusion

Changing the oil in your 2005 Yamaha TTR90 is an easy, essential maintenance task that ensures years of dependable riding. Always use the correct tools, confirm oil type and quantity for your model, and dispose of old oil responsibly. For all your dirt bike maintenance needs, trust MotoSport.com for high-quality parts, gear, and expert guides.

Related Shopping Categories

Shop Motor Oil for a 2005 Yamaha TTR90 Dirt Bike.

Shop Oil Filters for a 2005 Yamaha TTR90 Dirt Bike.

Shop Oil Drain Pans for a 2005 Yamaha TTR90 Dirt Bike.

Shop Tools for a 2005 Yamaha TTR90 Dirt Bike.

Shop Oil Fillers and Drain Plugs for a 2005 Yamaha TTR90 Dirt Bike.

Disclaimer: This guide is provided for general informational purposes only and is not intended to replace your motorcycle's official owner's manual. Always refer to your manufacturer's documentation for model-specific instructions, torque specifications, safety procedures, and maintenance requirements. If you are unsure or inexperienced, consider seeking assistance from a qualified mechanic or technician.