How the Fuel Line Comes Off and Goes Back On — 2017 Suzuki RM85
Shop parts for a 2017 Suzuki RM85 Dirt Bike.
Fuel line replacement sits near the top of the high-value, low-difficulty maintenance list on a 2017 Suzuki RM85. The hose is short, the fittings are simple, and the payoff is a fuel system you can stop worrying about. What follows covers identifying what you have, spotting a line on its way out, and getting the new one leak-free.
Red Flags During a Pre-Ride Look
A fuel line rarely fails without hinting first. Run through this list before loading the RM85 up, particularly if the bike has been sitting.
- Fuel staining at either fitting. Seepage shows up at the barbs before anywhere else.
- Persistent gasoline smell. If you smell fuel with the bike cold and untouched, something is leaking.
- Cracks that appear when you flex the hose. Dry rot hides at rest and reveals itself the moment rubber bends.
- Swelling or a soft, mushy section. The opposite of hardening and just as bad — usually chemical attack.
- Surging or dying under load. Restricted flow mimics fuel starvation and gets misdiagnosed as a jetting problem.
Understanding How the Line Deteriorates
Rubber fuel line fails for reasons that have little to do with how hard you ride. Age drives it: the plasticizers keeping the hose flexible slowly migrate out, and pliable rubber turns stiff and glassy, so a small flex — bolting the tank down, rocking the bike onto a stand — opens a hairline crack. Dry, hot storage accelerates that, pulling volatiles out faster than a temperate garage would. Ethanol-blended pump fuel left sitting in the hose adds a second mechanism, attacking the inner wall and leaving gum that can flake into the fuel path on a 2017 Suzuki RM85.
Start by Tracing the Fuel Path
The 2017 Suzuki RM85 runs a carbureted fuel system, which works in your favor. Fuel leaves the tank through a petcock — the small valve underneath — travels down a short rubber hose, and enters the carburetor at the float bowl inlet. You can shut fuel off at the source, and the line is a simple two-clamp affair with no pump pressure behind it.
What to Have on the Bench
Nothing here is exotic, but having it within reach before you open the fuel system keeps the job from turning messy.
- Replacement fuel line in the correct inside diameter and length for your 2017 Suzuki RM85. Match the original rather than guessing — oversized line will not seal on the barb.
- New clamps. Spring clamps lose tension with age, and a small clamp kit costs very little.
- Nitrile or rubber gloves. Gasoline absorbs through skin.
- A fuel-safe drain container and a funnel if you plan to reuse the fuel.
- Pliers and a small flat screwdriver for spring and screw clamps respectively.
- Shop rags and eye protection.
One genuine safety note: gasoline vapor is heavier than air and travels along the floor toward anything that can ignite it. Work outdoors or with the door open, shut off any heater with a pilot light, keep the fuel container capped, and let a hot engine cool first.
Working the Original Hose Free
Close the petcock. Everything downstream of that valve is the only fuel you need to deal with, which on a 2017 Suzuki RM85 amounts to a few ounces in the line and float bowl.
Get that remaining fuel into a container rather than onto the floor. The float bowl drain screw is purpose-built for this — slip a hose over the nipple, aim it into your catch can, and crack the screw open. If you would rather drain the whole tank, do it now with the hose routed into the container.
Then release both clamps and work the hose off the fittings. Pliers handle spring clamps; a flat screwdriver handles screw clamps. Slide each clamp well back so it cannot fight you. To separate a stubborn hose from a barb, rotate it a quarter turn to shear the bond before pulling. If the rubber has gone hard enough that it will not release, split it with a knife along its length — the hose is being replaced anyway, and the fittings are what matter.
Putting the Fresh Hose On
Measure the replacement against the old line before cutting. Matching the original length keeps routing correct on the RM85, and a square cut gives the clamp a clean surface to seal against. Trim with a fresh blade rather than dull side cutters.
Slide the hose fully onto the tank-side fitting, past the barb and up against the shoulder. If the rubber resists, soften it in hot water; do not reach for lubricant. Grease or oil on a fuel fitting shows up later as a slow weep and can carry contamination into the carburetor.
Attach the carburetor end and check the shape of the run. The hose should follow the original path with no contact against cylinder or exhaust and no kink where it curves. Install fresh clamps over the fitting area rather than out on bare hose, and tighten only until the rubber is compressed — a screw clamp cranked down hard will eventually cut through.
Verifying the Repair
Turn the petcock back on and give it time. Several minutes of sitting over clean cardboard will reveal a gravity leak that a quick glance would not. Inspect both connection points closely, by touch as well as by eye, since a slow weep often shows up as nothing more than dampness at the clamp.
Start it up next. Heat and vibration change the picture, so run the engine to temperature and inspect the joints again at idle. A leak appearing only when running usually means the hose is not seated deeply enough — take it apart and reseat rather than adding clamp tension, which only damages rubber.
Once it passes both tests, finish the housekeeping. Handle the drained fuel responsibly and think twice about reusing it if it has gone stale. Recheck the fittings after the first ride, since a new hose settles onto the barbs. Riders wanting a broader look at fuel line care and storage-related failures will find more in our broader walkthrough on dirt bike fuel line replacement.
Related Shopping Categories
Shop Fuel Lines for a 2017 Suzuki RM85 Dirt Bike.
Shop Fuel Line Clamps for a 2017 Suzuki RM85 Dirt Bike.
Shop Petcocks for a 2017 Suzuki RM85 Dirt Bike.
Shop Fuel Filters for a 2017 Suzuki RM85 Dirt Bike.
Shop Fuel Stabilizer for a 2017 Suzuki RM85 Dirt Bike.
Disclaimer: This guide is provided for general informational purposes only and is not intended to replace your dirt bike's official owner's manual. Always refer to your manufacturer's documentation for model-specific instructions, torque specifications, safety procedures, and maintenance requirements. If you are unsure or inexperienced, consider seeking assistance from a qualified mechanic or technician.